Polyquaternium-11by Naturallythinking Safety Data Sheet (SDS)

SDS for Polyquaternium-11

Safety Data Sheet (SDS) dated 22/05/2019

Batch Number: FRAMECPSR


Section 1: Identification of Product and Supplier

Product Name: Polyquaternium-11
Product Number: 5060330639450
Brand: Naturallythinking
Supplier: Naturallythinking, The Tramsheds, Coomber Way, Croydon, Surrey, CR0 4TQ
Contact Telephone: 020 8689 6489
Contact Email: support@naturallythinking.eu

Section 2: Hazards IDENTIFICATION

NFPA RATINGS (SCALE 0-4): HEALTH=0 FIRE=0 REACTIVITY=0 (POLYQUATERNIUM 11)

EC CLASSIFICATION (ASSIGNED): No classification assigned

EMERGENCY OVERVIEW: NO SIGNIFICANT TARGET EFFECTS REPORTED.

POTENTIAL HEALTH EFFECTS:

PRIMARY ROUTE(S) OF ENTRY: Contact

INHALATION:

SHORT TERM EXPOSURE: If misted , no effects of exposure expected

LONG TERM EXPOSURE: Same as effects reported in short term exposure.

SKIN CONTACT:

SHORT TERM EXPOSURE: No effects of exposure expected.

LONG TERM EXPOSURE: Same as effects reported in short term exposure.

EYE CONTACT:

SHORT TERM EXPOSURE: No effects of exposure expected with the exception of possible irritation.

LONG TERM EXPOSURE: Same as effects reported in short term exposure.

INGESTION:

SHORT TERM EXPOSURE: no effects of exposure expected

LONG TERM EXPOSURE: Same as effects reported in short term exposure.

CARCINOGEN STATUS: OSHA: N NTP: N IARC: N 

Section 3: Composition and information on Ingredients

Inci: Polyquaternium-11
Cas: 53633-54-8
Einecs:

Hazardous Components

Hazardous Components CAS-No. Concentration
Vinyl-N-Pyrrolidinone-2 88-12-0 >=0.1 <0.5%

 

Section 4: First aid measures

Eyes 

If symptoms develop, move individual away from exposure and into fresh air. Flush eyes gently with water while holding eyelids apart. If symptoms persist or there is any visual difficulty, seek medical attention. 

Skin 

First aid is not normally required. However, it is recommended that exposed areas be cleaned by washing with soap and water. 

Ingestion 

Seek medical attention. If individual is drowsy or unconscious, do not give anything by mouth; place individual on the left side with the head down. Contact a physician, medical facility, or poison control center for advice about whether to induce vomiting. If possible, do not leave individual unattended. 

Inhalation 

If symptoms develop, move individual away from exposure and into fresh air. If symptoms persist, seek medical attention. If breathing is difficult, administer oxygen. Keep person warm and quiet; seek immediate medical attention. 

Notes to physician 

Hazards: No information available. 

Treatment: No information availablePersonal precautions For personal protection see section 8. Persons not wearing protective equipment should be excluded from area of spill until clean-up has been completed. Environmental precautions Prevent spreading over a wide area (e.g. by containment or oil barriers). Do not let product enter drains. Do not flush into surface water or sanitary sewer system. Methods for cleaning up Keep in suitable, closed containers for disposal. Soak up with inert absorbent material (e.g. sand, silica gel, acid binder, universal binder, sawdust). Other information Comply with all applicable federal, state, and local regulations.

Section 5: Fire - Fighting measures

Suitable extinguishing media 

Dry chemical, Carbon dioxide (CO2), Water spray 

Hazardous combustion products 

No data 

Precautions for fire-fighting 

Wear full firefighting turn-out gear (full Bunker gear), and respiratory protection (SCBA). DO NOT direct a solid stream of water or foam into hot, burning pools of liquid since this may cause frothing and increase fire intensity. Frothing can be violent and possibly endanger any firefighter standing too close to the burning liquid. Use water spray to cool fire exposed containers and structures until fire is out if it can be done with minimal risk. Avoid spreading burning material with water used for cooling purposes. 

NFPA Flammable and Combustible Liquids Classification 

Combustible Liquid Class IIIB

Section 6: Accidental release measures

Personal precautions

For personal protection see section 8. Persons not wearing protective equipment should be excluded from area of spill until clean-up has been completed.

Environmental precautions

Prevent spreading over a wide area (e.g. by containment or oil barriers). Do not let product enter drains. Do not flush into surface water or sanitary sewer system.

Methods for cleaning up

Keep in suitable, closed containers for disposal. Soak up with inert absorbent material (e.g. sand, silica gel, acid binder, universal binder, sawdust).

Other information

Comply with all applicable federal, state, and local regulations.

Section 7: Handling and Storage

Handling

Containers of this material may be hazardous when emptied. Since emptied containers retain product residues (vapor, liquid, and/or solid), all hazard precautions given in the data sheet must be observed.

Storage

Store in a cool, dry, ventilated area. 

Section 8: Exposure controls and personal protection

Exposure Guidelines

Contains no substances with occupational exposure limit values.

General advice

These recommendations provide general guidance for handling this product. Personal protective equipment should be selected for individual applications and should consider factors which affect exposure potential, such as handling practices, chemical concentrations and ventilation. It is ultimately the responsibility of the employer to follow regulatory guidelines established by local authorities.

Exposure controls

Provide sufficient mechanical (general and/or local exhaust) ventilation to maintain exposure below exposure guidelines (if applicable) or below levels that cause known, suspected or apparent adverse effects.

Eye protection

Not required under normal conditions of use. Wear splash-proof safety goggles if material could be misted or splashed into eyes.

Skin and body protection

Wear resistant gloves (consult your safety equipment supplier). Wear normal work clothing including long pants, long-sleeved shirts and foot covering to prevent direct contact of the product with the skin. Launder clothing before reuse. If skin irritation develops, contact your facility health and safety professional or your local safety equipment supplier to determine the proper personal protective equipment for your use.

Respiratory protection

A NIOSH-approved air-purifying respirator with an appropriate cartridge and/or filter may be permissible under certain circumstances where airborne concentrations are expected to exceed exposure limits (if applicable) or if overexposure has otherwise been determined. Protection provided by air-purifying respirators is limited. Use a positive pressure, air-supplied respirator if there is any potential for uncontrolled release, exposure levels are not known or any other circumstances where an air-purifying respirator may not provide adequate protection. 

Section 9: Physical data and chemical properties

Physical State Liquid
Form Viscous
Colour Cloudy
Odour None
pH 5.5 - 7.0
Flash Point  220.1 F / 104.5C
Density 1g/cm3 @ 68 F / 20c
Water solubility Soluble
   

 

Section 10: Stability & Reactivity

Stability

Stable.

Conditions to avoid

None known.

Incompatible products

None known.

Hazardous decomposition products

No data

Hazardous reactions

Product will not undergo hazardous polymerization.

Section 11: Toxicological Information

Information on likely routes of exposure :

Inhalation

Skin absorption

Skin contact

Eye Contact

Ingestion

Product

Acute oral toxicity : LD 50Rat > 5,000 mg/kg

Acute inhalation toxicity : no data available

Acute dermal toxicity : no data available

Skin corrosion/irritation :

Species: Rabbit

Result: Not irritating to skin

Serious eye damage/eye irritation :

Species: Rabbit

Result: Not irritating to eyes

Respiratory or skin sensitisation :

Classification: Did not cause sensitisation on laboratory animals.

Result: Did not cause sensitisation on laboratory animals.

VINYL-N-PYRROLIDINONE-2:

Acute oral toxicity : LD 50 Rat: 1,022 mg/kg

Acute inhalation toxicity : LC 50 Rat: 3.07 mg/l Exposure time: 4 h

Acute dermal toxicity : LD 50 Rabbit: 560 mg/kg

Respiratory or skin sensitisation : Test Method: Buehler Test Species: guinea pig Result: Did not cause sensitisation on laboratory animals.

Germ cell mutagenicity

Genotoxicity in vitro :

Type: Ames test Result: negative : Type: Chromosome aberration test in vitro Result: negative

Genotoxicity in vivo :

Type: In vivo micronucleus test Test species: mouseResult: negative

Repeated dose toxicity :

Rat: NOAEL: 0.023 mg/l

Application Route: Inhalation

Exposure time: 90-day

Target Organs: Liver

Section 12: Ecological information

Ecotoxicity

Product:

Toxicity to fish : LC 50 (Oncorhynchus mykiss (rainbow trout)): 4.47 mg/l Exposure time: 96 h

Toxicity to daphnia and other aquatic invertebrates : EC 50 (Water flea (Daphnia magna)): 177.1 mg/l Exposure time: 48 h

Components:

no data available

Persistence and degradability

Product

Biodegradability :

Not readily biodegradable.

Components:

VINYL-N-PYRROLIDINONE-2:

Biodegradability :

Biodegradation: 100 % Exposure time: 28 d Readily biodegradable

Bioaccumulative potential

Product:

no data available

Components:

VINYL-N-PYRROLIDINONE-2:

Partition coefficient: noctanol/water : log Pow: 0.4 (25 °C)

Mobility in soil

Product:

no data available

Components:

no data available

Section 13: Disposal considerations

Waste disposal methods

Dispose of in accordance with all applicable local, state and federal regulations. 

Section 14: Transport information

No classification assigned. 

Section 15: Regulatory information

This product is not classified as hazardous under the terms of EEC Directive 67/548/EEC, UN Regulations or the European ADR/RID Agreements. 

Section 16: Other information

References:

European Chemicals Agency

European Chemicals Bureau

European Regulations and Directives

Published chemical directories

Suppliers’ safety data sheets

UK Health and Safety Executive

US Environmental Protection Agency

Risk Phrases

R38: Irritating to skin.

R41: Risk of serious damage to eyes.

Safety Phrases

S25: Avoid contact with eyes.

S26: In case of contact with eyes, rinse immediately with plenty of water and seek medical advice.

S39: Wear eye/face protection.

Hazard statement(s)

H315: Causes skin irritation.

H318: Causes serious eye damage.

Precautionary statement(s)

P262: Do not get in eyes, on skin, or on clothing.

P280: Wear protective gloves/protective clothing/eye protection/face protection.

P305 + P351 + P338 : IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing.

GMO Declaration

We declare that at present all our regisered and commercially available ingredients, extracts, oils, plants and skincare products are derived by traditional plant breeding methods. We do not have any ingredient, extract, oil or skincare product from genetically modified material

To the best of our knowledge, the information contained in the sheet is correct. However, we cannot accept responsibility for any consequences from its use.

Animal Testing Declaration

WE DO NOT TEST ANY OF OUR PRODUCTS ON ANIMALS AND NEVER HAVE, WE PREFER TO RELY ON OUR KNOWLEDGE OF ESSENTIAL OILS, INGREDIENTS, PLANTS, FLOWERS AND ESTABLISHED TECHNICAL INFORMATION AND PROFESSIONALS TO ENSURE EFFECTIVE AND SAFE PRODUCTS.

We believe there is already a “safe” and known group of product ingredients used in the cosmetics industry which leave enough scope to be creative and innovative in product formulation without the need for anymore animal testing on new experimental ingredients.

Our suppliers each also agree to not to carry out animal testing on the products and ingredients we purchase. We have a self-imposed cut-off date of 2006 (this was the date our cosmetic formulations came into being) although in reality our suppliers normally have animal testing dates far in excess of this or have never tested at all.

We do not conduct any form of animal testing.

We do not commission any form of animal testing from a third party.

We operate a fixed cut-off date for animal testing and ingedients, which means we will not use any ingredient that has been tested or retested on animals for cosmetics purposes since January 1, 2006

If we find that a company is involved in animal testing in anyway that purchases from us, then we will cease supply immediately. It is a term and condition that by purchasing from Naturallythinking you will not involve yourself or your company in any form of Animal Testing, any violation of this will be dealt with as per any violation of our terms and condtions